Sunday, 21 December 2014

Circuit breaker ratings: Under fault conditions the C.B. should perform the following three duties:
i)        It must be capable of opening faulty circuit and breaking the faulty current.
ii)       It must be capable of being closed on to a fault.
iii)      It must be capable of carrying fault current for a short time while another, is clearing the fault.
Corresponding to above thing C.B. has three ratings:
1) Breaking capacity: It is the current (r.m.s.) that a C.B. is capable of breaking at given recovery voltage and under specified conditions (e.g. p.f., RRRV).
It is a common practice to express the breaking capacity in MVA by taking into account rated breaking current and rated service voltage.
Breaking capacity = 3 x V x I x 10-6 MVA
2) Making Capacity: The peak value of current (including D.C. component) during the first cycle of current wave after closure of circuit breaker is known as making capacity.
The C.B. may be closed in S.C. conditions. The electromagnetic forces are produced which are proportional to square of the maximum instantaneous current of closing. So making capacity is expressed in peak value instead of r.m.s. and the maximum value of fault current is in the first cycle.
Making capacity = 2.55 x Symmetrical breaking capacity
3) Short Time Rating: It is the period for which C.B. is able to carry fault current while remaining closed. Sometimes fault occurred in a system may be of temporary nature and it occurs only for 1 to 12 sec. and afterwards it is cleared automatically. They should not trip in such conditions i.e. it should be able too carry this large current for a very few time i.e. short time rating. If fault persists for longer time than specified limit then should trip.
The short time rating depends upon: i) Electromagnetic force, ii) Temperature rise.
4) Normal Current Rating: It is the r.m.s.  value of current which the C.B. is capable of carrying continuously at its rated frequency under specifie4d conditions.
Formulae to be remembered:
                                                                            √3 x Recovery voltage
1.           Peak re-striking voltage  =   -------------------------------  x 2 = 2 Emax
                                                                                             √3
2.      Frequency of oscillations fn = 1/2t  Time up to 1st peak

                                                          Peak re-striking voltage
3.                     Average RRRV      = --------------------------------
                                                                         T
                                                                       1
4.      Frequency of oscillations fn  = --------------------           
                                                                  2π√LC
Difference between Isolator and Circuit Breaker
Sn
Isolator
Sn
Circuit Breaker
1
Operation is on no load.
1
Operated ON-load/on occurrence of fault.
2
No arcing during ON-OFF so no arc quenching provision
2
The current is interrupted and hence heavy arc is produce. Arc quenching facility is provided
3
It’s operation is manual or manual plus mechanical or pneumatic.
3
Manually operated in normal condition and automatic tripping in fault condition.
4
No definite current capacity and specifications.
4
CBs. Are specified by breaking capacity, making capacity, etc.
5
Visible operation in open-air (opening and closing of contacts).
5
Operation in the oil or gas chamber (not visible).
6
Noise-less operation.
6
Big sound on operation.
7
Cheaper.
7
Costly.
8
No periodic maintenance required only contact cleaning.
8
Periodic maintenance is necessary.
9
Types are very few:
a)     Vertical breaking,
b)     Horizontal breaking,
c)     Pentagonal type.
9
Vide varies like, Air break CB, ABCB, MCB, MCCB, OCB, SF6, DCB VCB etc.
10
For safety and mal-operation it is interlocked.
10
CB and isolators interlocked to avoid mal-operation.
11
Occupy less space.
11
Occupy more space.
12
No tripping circuit.
12
Requires tripping circuit for operation.
CIRCUIT BREAKERS
Concept of Circuit Breakers
Power system consists of generating plants, transformers, transmission line, distributors etc. Many times it is essential to switch off the various circuits for maintenance work or due to occurrence of fault. In earlier days, i.e. during 1890 switch fuse unit was used for this purpose. Switch fuse unit is inserted in series with the circuit. On occurrence of fault the fuse blows out, the switch is then opened and the fault finding is done and fault is cleared. Then a new fuse is put, switch is closed and thus supply is restored. So a lot of time is required to restore the supply.
Modern power system operates with high voltage so heavy fault current is there, the fuse cannot interrupt is effectively. So this switch fuse unit cannot be used for such purpose.
The use of switch fuse unit is for low voltage circuits where frequent operations do not occur e.g. distribution transformer circuits, lighting circuits etc.
For modern power system a more reliable switchgear is required because switch fuse unit cannot effectively interrupt heavy fault current. So a more dependable device is required and that is circuit breaker. A circuit breaker can make or break a circuit either manually or automatically on occurrence of fault (short circuit etc). If required it can be operated during normal working conditions also for the purpose of maintenance of any device, circuit etc.
The automatic operation of circuit breaker takes place with the help of relays and CTs. 
Operating Principle
A protective relay detects abnormal conditions and sends a tripping signal to circuit breaker. After receiving the trip command from relay, the circuit isolates the faulty part of the power system. This is the principle of operation for all types of circuit breakers.
A circuit breaker has two contacts fixed contact and moving contact.
                                               
Under normal operating conditions these contacts remain closed. When fault occurs on any part of the system, the trip signal is received and moving contacts moves away, thus circuit is interrupted. This results into formation of arc. This arc is to be extinguished or quenched at the earliest.
These contacts are placed in a closed chamber. The chamber is filled up with some insulating medium (liquid or gas) which extinguishes the arc. The insulating medium used for arc extinction is usually oil, air, vacuum, SF6 gas (sulphur hexa floride).
Classification of Circuit Breaker: The basic classification of circuit breaker is made on the basis of insulating medium used for extinction of arc. The classification can be further made on the basis of operating voltage of the system i.e. HT and LT.
Following three pattern shows classification of CBs.
                                                Circuit breaker(C.Bs.)
                                                                       
 


        
        
           C.Bs used for HT                                                   CBs used for LT
 


Oil CBs    SF6 CB         Vacuum CB       
 


Bulk Oil CB       Min. Oil CB
 


Plain Break             Arc control                   Air CB        Miniature       Molded Case           Earth leakage
Oil CB                     oil CB                                           CB(MCB)               CB                        CB (ELCB)

Medium used for arc extinguishing;
1.    Oil circuit breaker – insulating oil – transformer oil.
2.    Air blast circuit breakers – high pressure air-blast.
3.    SF6 circuit breakers – SF6 – gas
4.    Vacuum circuit breaker – vacuum.
Properties of C.B. Contacts
1.    The contact area should be well defined.
2.    Contacts should have low contact resistance to avoid over heating.
3.    The contact pressure should be adequate.
4.    The contact materials should be of self cleaning type because the thin oxide films are developed at the surface of contacts.
5.    The tips of the contacts should be replaceable, so that entire contact assembly need not be replaced.
6.    Contacts grip is an important electromagnetic phenomenon and the grip should not be loosen under the operation of the electromagnet forces.
7.    Contact material should be able to carry load current without a temperature rise.
8.    Contact material should carry S.C. current for a short duration without deterioration.
Contact Materials
The materials, used for C.B. contact are generally copper, silver and various alloys. These materials must have ionization energies between 12 to 16 volts.
Operating mechanism of C.Bs.: The different types of operating mechanisms are:
1.    Hydraulic mechanism
2.    Pneumatic operating mechanism
3.    Spring operated (spring opened and spring closed) mechanism: used in miniature CBs.
4.    Solenoid operated mechanism.
Expected Properties of Operating Mechanisms of CBs
Next to the arc extinguishing chamber the important element is the operating mechanism. Due to this mechanism correct operation of CB is assured. The mechanism should be such that:
i)       It must close the CB contacts within a few tenths of a second which in the case of high surge currents.
ii)     Its trip mechanism must e prepared to open the CB contacts within a few milliseconds
iii)    Design of mechanism must withstand to face heavy stresses, so I should be robust and reliable and mechanically strong.
Mechanisms Available are of the Following Types:
1. Hand operated type: Suggested for low capacity breakers only. Energy required for operation is supplied by human muscles. The mechanism is very cheap in cost. But is not useful in modern power system.
2. Solenoid operated mechanism: This mechanism is also very simple and not so costly. Electrical energy of an electromagnet (solenoid) is transferred to mechanical energy necessary to close the CB.
Drawbacks and limitations: Heavy power demand for operation. Solenoid coil requires time to get in operation. It gives low initial acceleration. The speed of operation is reduced. So is not suggested for high power circuits.
1.    Motor operated mechanism: This mechanism also suffers due to longer “make time”. In this mechanism, the necessary mechanical power is supplied by D.C. or A.C. motor. The advantage is not power required for operation of mechanism is comparatively lesser.4.
2.    Motor operated spring-mechanism: In this type, the spring is charged compressed by previous operation of electric motor and thus energy is stored in it. Therefore, the closing operation is affected by releasing the compressed spring. So making time is very short and depends on elasticity of the spring. Motor required for the mechanism is of small capacity. Shock due to contact closing of CB is small. The mechanism is suitable for high power circuits.

5. Pneumatically operated mechanism: In this type, potential energy of compressed air is made use for operation of mechanism. The speed of operation is much more. Quick reversal of breaker moving parts for re-closer is possible because of low inertia of the operating piston. Force exerted by compressed air is mostly uniform.

No comments:

Post a Comment